terclim by ICS banner
IVES 9 IVES Conference Series 9 INSIGHT THE IMPACT OF GRAPE PRESSING ON MUST COMPOSITION

INSIGHT THE IMPACT OF GRAPE PRESSING ON MUST COMPOSITION

Abstract

The pre-fermentative steps play a relevant role for the characteristics of white wine [1]. In particular, the grape pressing can affect the chemical composition and sensory profile and its optimized management leads to the desired extraction of aromas and their precursors, and phenols resulting in a balanced wine [2-4]. These aspects are important especially for must addressed to the sparkling wine as appropriate extraction of phenols is expected being dependent to grape composition, as well. To the best of our knowledge, a gap exists regarding grape composition – pressing conditions – must composition. To fulfill this gap and support the wine industry, this research aimed to clarify the impact of grape pressing based on both grape and must composition.

Chardonnay (7 samples) and Pinot blanc (2 samples) grapes were collected in vintage 2022 from different vineyards in Franciacorta area (Lombardy, Italy). These grapes were used to produce musts under an industrial scale following the pressing conditions adopted by wineries. Must samples were obtained at different extraction yields (e.g. running juice, 20, 30 [first fraction], 40, 50 [second fraction], 60 and 70 [third fraction] % must yields). The chemical parameters, turbidity units (NTU), color index (ABS 420 nm), total phenol index (TPI), polyphenol oxidase (PPO) activity and antioxidant capacity (AC) were assessed in both grape and must samples.

A decreasing trend of readily assimilable nitrogen and titratable acidity was found in must samples with higher extraction yields, while the opposite was observed for pH, NTU, color index, TPI and AC with a different extend dependent from the grape varieties and pressing conditions. Considering the first fraction must, a high variability in phenol extraction was found, from 16% to about 35%. Such a difference could be attributable to the different pressing conditions adopted as comparable levels of TPI were detected in grapes used (1.7-2.2 g/L, RDS=10%). The PPO activity seemed to be unaffected by the increased must extraction yield. Grape variety was influential on phenol content for the same must yield being higher for Pinot blanc probably due to its thinner skin in comparison to Chardonnay.

This study suggests the phenol-related indexes should be considered in addition to the chemical parameters for the accurate management of the pressing step; it also has been clarifying the relation existing between the composition of grape and must.

 

1. Gawel R., Day M., Van Sluyter S.C., Holt H., Waters E.J., Smith P.A. (2014). White wine taste and mouthfeel as affected by juice extraction and processing. J. Agric. Food Chem. 62, 10008–10014. https://doi.org/10.1021/jf503082v
2. Ferreira-Lima N.E., Burin V.M., Caliari V.,  Bordignon-Luiz M.T. (2016). Impact of pressing conditions on the phenolic com-position, radical scavenging activity and glutathione content of Brazilian Vitis vinifera white wines and evolution during bottle ageing. Food Bioprocess. Technol. 9, 944–957. https://doi.org/10.1007/s11947-016-1680-7
3. Lukic I., Horvat I., Radeka S., Damijanic K., Staver M. (2019). Effect of different levels of skin disruption and contact with oxy-gen during grape processing on phenols, volatile aromas, and sensory characteristics of white wine. J. Food Process. Preserv. 201943, e13960. https://doi.org/10.1111/jfpp.13969
4. Del Fresno J.M., Cardona M., Ossorio P., Loira I., Escott C., Morata A. (2021). White must extraction. In: White Wine Techno-logy. Academic Press. https://doi.org/10.1016/B978-0-12-823497-6.00013-2

DOI:

Publication date: February 9, 2024

Issue: OENO Macrowine 2023

Type: Poster

Authors

Gvantsa Shanshiashvili¹, Marta Baviera¹, Antonio Tirelli¹, Daniela Fracassetti1,*

1. Department of Food, Environmental and Nutritional Sciences (DeFENS), Università degli Studi di Milano, Via G. Celoria 2, 20133 Milan, Italy 

Contact the author*

Keywords

White grape, Must extraction, Sparkling wine, Phenols

Tags

IVES Conference Series | oeno macrowine 2023 | oeno-macrowine

Citation

Related articles…

GRAPE SPIRITS FOR PORT WINE PRODUCTION: SCREENING THEIR AROMA PROFILE

Port is a fortified wine, produced from grapes grown in the demarcated Douro region. The fortification process consists in the addition of a grape spirit (77% v/v) to the fermenting juice for fermentation interruption, resulting in remaining residual sugars in the wine and increased alcohol content (19-22%). The approval of grape spirits follows the Appellation (D.O. Port wine) rules1 and it is currently carried out based on analytical control and on sensory evaluation done by the public Institute that upholds the control of the quality of Douro Appellation wines. However, the producers of Port wines would like to have more information about quality markers of grape spirits.

Read More

THE INFLUENCE OF COMMERCIAL SACCHAROMYCES CEREVISIAE ON THE POLY-SACCHARIDES AND OTHER CHEMICAL PROFILES OF NEW ZEALAND PINOT NOIR WINES

Wine polysaccharides (PS) play an important role in balancing mouthfeel and stability of wine and even influence aroma volatility. Despite this, there is limited research into the effect of winemaking additives on the polysaccharide profile and other macromolecules of New Zealand (NZ) Pinot noir wine. In this study the influence of a selection of commercial S. cerevisiae strains on the chemical profile, including polysaccharides, of New Zealand Pinot noir (PN) wine was investigated. Research scale PN fermentations using five strains of commercially available S. cerevisiae (Lalvin EC1118 and RC212, Levuline BRG YSEO, Viallate Ferm R71 and R82) were undertaken. PS were qualified and quantified using HPLC-RID.

Read More

ANTHOCYANINS EXTRACTION FROM GRAPE POMACE USING EUTECTIC SOLVENTS

Grape pomace is one of the main by-products generated after pressing in winemaking.Emerging methods, such as ultrasound-assisted extraction with eutectic mixtures, have great potential due to their low toxicity, and high biodegradability. Choline chloride (ChCl) was used as a hydrogen bond acceptor and its corresponding hydrogen bond donor (malic acid, citric acid, and glycerol: urea). Components were heated at 80 °C and stirred until a clear liquid was obtained. Distilled water was added (30 % v/v). A solid-liquid ratio of 1 g pomace per 10 ml of eutectic solvent was used.

Read More

CHARACTERIZATION AND ANTIBACTERIAL ACTIVITY OF A POLYPHENOLIC EXTRACT OBTAINED BY GREEN SUPERCRITICAL CO₂ EXTRACTION FROM RED GRAPE POMACE

Upgrading wine industry solid wastes is considered as one of the main strategies to support the circular economy. Red grape pomaces constitute a rich source of polyphenols, which have been shown to possess antioxidant properties and to provide benefits for human and animal health. The objective of this work was to obtain and characterise polyphenolic extracts from red grape pomaces via green supercritical CO₂ extraction using ethanol as a co-solvent, and to evaluate their antibacterial activity against susceptible and multidrug-resistant Escherichia coli strains of animal intestinal origin.

Read More

AN AUTOMATIC CANOPY COOLING SYSTEM TO COPE WITH THE THERMAL-RADIATIVE STRESSES IN THE PIGNOLETTO WHITE GRAPE

In recent years characterized by hot dry summers, the implementation of innovative irrigation tools in the vineyard represents a crucial challenge to ensure optimal production and to avoid excess of water consumption. It is known that the grapevine reacts to multiple stresses – i.e., high temperatures and wa- ter shortage – through adaptive mechanisms that are detrimental to the yield. Furthermore, this condi- tion is usually aggravated by high solar radiation, which could negatively affect the phenolic composi- tion of the grapes. Therefore, a cooling system has been developed aiming to reduce bunches’ sunburn damage.

Read More